BMW · Model Report
Showing safety data for the 2001 model year only.
BMW of North America, LLC (BMW) is recalling certain 2000-2001 BMW 3 Series (323Ci, 325Ci, 328Ci and 330Ci), 1999-2001 323i, 328i, 330i, 330xi, and 2000 323i, 328i stationwagon vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata. These vehicles are equipped with driver-side air bag inflators that were previously inspected, but not replaced under recall numbers 19V-851, 19V852, or 19V-853. Due to a manufacturing issue, the NADI inflator may absorb moisture, causing the inflator to explode or the air bag cushion to underinflate.
BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
BMW of North America, LLC (BMW) is recalling certain 1999-2001 323i, 325i, 328i and 330i and 2000-2001 323Ci, 325Ci, 328Ci, 330Ci, 323iT, and 325iT vehicles equipped with Non-Azide Driver air bag Inflators (NADI) manufactured by Takata. These vehicles may have received a replacement driver air bag as part of a vehicle repair. Due to a manufacturing issue, the replacement NADI inflator may absorb moisture, causing the inflator to rupture or the air bag cushion to underinflate.
BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
-My infrastructure system management has been affected overtime—which covers electronic control units (ECUs), software, and network architecture—are driven by the need to manage increasing system complexity, cybersecurity vulnerabilities, and electronic malfunctions. -My De-icing fluid management system-Has been affected by potential engine damage, reduced structural integrity, and risk of in-flight failure due to overheating. -My vehicle has been affected sense March 3, 2025 - Major Terminal Outage: A massive power outage, traced to a fire and downed power line near the airport, I [XXX] [XXX] believe my Power failures and component-level are faulty… -My vehicles brake lines are not meeting specifications, which could cause leaks & affect the Antilock Brake System (ABS) and Dynamic Stability Control (DSC), increasing the risk of a crash god forbid… I [XXX] [XXX] believe my brake system is faulty. -My Takata driver-side airbag inflators has been affected that can explode upon deployment, spraying metal shrapnel and causing severe injury or death, (Models affected)~2000-2015 series with urgent "Do Not Drive" warnings requiring free, immediate dealer replacement required by (NHSTA)… I [XXX] [XXX] believe my Takata system is faulty. -My water pump system is electrical connector, authorized by NHTSA. Insufficient sealing allows fluid ingress, posing a short circuit and fire risk to prevent hazards… in conclusion, there has been several major BMW safety recall been mandated by the National Highway Traffic Safety Administration. Remedy plan must be completed within 5 days & I would like a copy of reports via email for my lawyer to review my vehicles standards. In conclusion, I need an evaluation appointment & determination assessment asap due to moving after Valentine’s Day to prevent serious safety issues on my journey to Florida. I’m currently 15min from 6312 Aaron Ln Clinton,Md closest & more convenient service center. Thanks for your understanding! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA
No injuries · No fire · No crash
The contact owns a 2001 BMW 330I. The contact stated that while attempting to drive into the driveway, the contact attempted to depress the brake pedal however, the accelerator was inadvertently depressed. The engine revved up while depressing the brake pedal. There was no warning light illuminated. The contact shifted into park to stop the vehicle and then engaged the parking brake after stopping the vehicle. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 188,000.
No injuries · No fire · No crash
The bracket welds on the front of the right side fuel tank support strap pulled out while on the highway, leaving the fuel tank supported by only one strap. The bracket pulled right out of the sheet metal, leaving two holes where it was previously spot welded to. The support strap itself was hanging off its rear mount, dragging behind the car and potentially sparking. This was extremely dangerous, as the tank had just been filled, and if the tank had began to leak, the support strap may have sparked a fire. There was no symptom or warning sign of the impending failure. There are many reports of this issue from other BMW E46 owners. Fuel tanks should not separate from the car under normal driving conditions. The car has been in southern California its entire life, and there is zero evidence of rust or poor maintenance. Records of the car's maintenance history have been meticulously maintained. This is DANGEROUS and has been reported many times. Please make BMW own up to this poor design and potentially save someone's life.
No injuries · No fire · No crash
The contact owns a 2001 BMW 330I. The contact stated that an indicator light had appeared on the instrument panel indicating that the rear taillights were inoperable. Upon investigation, the contact discovered a service bulletin (SIB630611) which he linked to the failure. The dealer was then notified of the service bulletin and the dealer informed him that his vehicle was not manufactured during the eligible period for the repair. The manufacturer was also notified of the failure and gave the contact the same information as the dealer; he was then referred to the NHTSA for assistance. The vehicle had yet to be repaired. The failure mileage was unknown.
No injuries · No fire · No crash
Hi, my name is [XXX] and the owner of the 2001 BMW mentioned with the VIN number above. My airbag deployed for no reason as I was driving with my mother in the car on Tuesday the 26th of November around 5:30 p.m.. , the airbag deployed for no reason at all I was doing the speed limit, driving with the flow of traffic on Paramount Boulevard in the city of Paramount or borderline Downey I'm not sure in California. There was no accidents all the car did not hit any other cars or anything while this incident occurred. I me and my mom really lucky to be alive. Although the injuries from the incident was in catastrophe however we do have a lot of small injuries and side effects that seems to be developing more as time goes by. The seriousness of this incident is at a very high level as it could have caused it for both of us or one of us. I was in shock Mordor though I just dropped the car when it exploded I'm referring to the airbag I was driving and suddenly I feel something should pass my left side touching my ear and my shoulder and exploited almost in my face on my left side. I thought a bomb exploded or someone tried to shoot at my car I did not know what happened until I got my thoughts together and I just asked your mom if she was okay glasses had fell off and she was in a very bad shock more my mother is 74 years old and he did not have to go through this traumatic experience. It was very traumatic for both of us and it took a while for us both to realize and figure out what happened. All we knew there was a big explosion and something on my left side was there that I have never seen before. Keeping in mind that I have never been in this airbag situation before it really was confusing and I had no idea what it was in the beginning or we could smell was strong gas I believe it is nitrogen that deploys from the airbag and there was debris every way. There is a lot of injuries and side effects caused by this & I need help. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)